Local News

Actions

VW has only a few options to fix diesels

VW has only a few options to fix diesels
Posted at 2:48 PM, Nov 19, 2015
and last updated 2015-11-19 17:48:51-05

DETROIT (AP) — When Volkswagen submits a plan to fix emissions-cheating diesel engines on Friday, it will have only two options for most of the cars.

It can install a bigger exhaust system to trap harmful nitrogen oxide, or it can retrofit a chemical treatment process that cuts pollution.

The bigger exhaust will likely hurt performance and gas mileage, angering car owners. But the chemical treatment, while saving acceleration and mileage, needs a clumsy storage tank and multiple hardware changes to work. In either case, almost a half-million cars would have to be recalled for the repairs.

Experts say both options will be expensive, perhaps so costly that it will be cheaper to buy back some of the older models.

"I think they know right now how to do the fix," said Alan Baum, a consultant in Detroit who advises automakers on fuel-economy regulations. "The harder part of this is ... how do you actually execute it?"

VW has until Friday to submit a draft plan to fix four-cylinder diesels to the U.S. Environmental Protection Agency and the California Air Resources Board, the two agencies that forced the German automaker to admit to the cheating. The company was to meet with the agencies on Thursday, with a final submission on Friday. VW's board also is to meet Friday and may discuss the repairs.

The plan, which is likely to have several options for regulators to consider, must be tested by the agencies to make sure the fixes comply with pollution laws. Testing and installation could take more than a year.

In September, Volkswagen admitted that about 482,000 U.S. cars with 2-Liter diesel engines from the 2009 through 2015 model years have software that turns pollution controls on during government treadmill tests and shuts them off when on real roads. As a result, the cars emit 10 to 40 times the allowable limit of nitrogen oxide, a chemical ingredient of smog that can cause breathing problems.

The U.S. admission triggered a much larger one for the rest of the world: VW has said another 10.5 million cars worldwide have the same deceptive software and will need to be repaired.

In addition, the EPA has accused VW of cheating a second time, programming about 10,000 VW and Audi vehicles with larger six-cylinder diesel engines to emit fewer pollutants during tests than in real-world driving. The company also has withdrawn its application to get emissions controls approved on four-cylinder diesels for the 2016 model year, and the government is investigating whether VW cheated on those.

Any recall would affect Jetta, Golf, Beetle, Passat and Audi A3 four-cylinder diesels. About 157,000 of those cars from 2015 plus 2012-2014 Passats likely can be fixed with relatively simple software changes. But 325,000 of the cars from 2009 to 2014 will need the complex and expensive hardware fixes as well as software. VW U.S. CEO Michael Horn has said it could take a year or longer for those cars to be fixed.

The most likely fix for the bulk of the cars is a treatment system with urea, a chemical that's injected into the exhaust system and helps separate nitrogen oxide into harmless nitrogen and oxygen.

The company also could use a bigger nitrogen oxide trap, but engine settings would have to be changed to flush it out periodically, and that would cut into performance and gas mileage.

John German, senior fellow with the International Council on Clean Transportation, the group that sponsored the on-road testing that exposed the cheating, said the older VWs were not designed to handle urea treatment systems, making a solution a complex challenge for engineers.

Space must be found for the urea storage tank, possibly taking precious trunk room. Urea can freeze, so the storage tank must be kept warm. The urea tank has to be refilled periodically, so a refilling method has to be designed and installed. Lines have to be run to take urea from the tanks to the exhaust system and an injection system added, said German, who estimates that hardware, design, and installation costs would likely exceed $1,000 per car.

"They probably didn't plan on nitrogen oxide after-treatment when they designed the floor pan," German said.

Volkswagen wouldn't comment Thursday on a possible fix. A spokeswoman said the company is cooperating with the agencies. The EPA and the California Air Resources Board would not comment.